2004 Toyota Sienna Frame And Members Problems
- 19
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- sliding door · 9 records
- door close · 4 records
Mileage in stored records
| Band | Records |
|---|---|
| 30–60k mi | 7 |
| 60–100k mi | 5 |
| 100–150k mi | 4 |
| 1–30k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Frame And Members · Latches/Locks/Linkages
2004 toyota sienna van drivers side sliding door rear latch has become detatched and the door won't close. Not only is this a safety hazard while driving but the locks will not engage with an open door. *tr
ODI 10376498
Frame And Members
I bought a 2004 toyota sienna in march 2004. August 2010, i noticed that the driver's side door did not close smoothly & noticed that the door stop (midway between hinges) was busted. I bought the part & thought this was all that needed to be replaced. It got really bad really fast to the point that the door made a lot of popping when i opened & closed it & it was becoming difficult to open & close. On august 17th i…
ODI 10375525
Body · Frame And Members
I have a 2004 toyota sienna. I have slider doors that i have been operating manually for several months as they were broken and were too expensive to fix. I was closing the slider door today when it popped off its' track and smashed into the back window of the van spraying huge chunks of glass all over the back seat. The slider door was hanging off the van about a foot away from the van. There were three little…
ODI 10328690
Body · Frame And Members · Latches/Locks/Linkages · Structure
Plastic sheathing on passenger power door, the only power door, dried out and cracked causing the cable wires to be exposed to the elements. As a result, the wires of the cable began to rust and fray and tangled in the door so that it was half opened and would neither open nor close even with the power off. We had to cut the cable off to get the tangled cable free of the door so we could close it. It is poor quality…
ODI 10319274
Frame And Members
I own a toyota sienna 2004 van and there has been this persisting and irritating popping sound when you open and close the driver side door. I called toyota and they said that the vehicle is no longer covered by the warranty. Nothing was done by toyota, so i had to had it repaired by myself at my expense. *tr
ODI 10344252
Electrical System · Frame And Members
Power sliding door on my van quit working. Door is stuck half opened. Took to toyota said it was a common problem but the warranty wont cover. They said it was due to door sag due to hinge but this is not the case i cut a steel cable and was able to close the door manually. It works fine manually you would think it was due to what they said it wouldn't close at all. Many people are having this problem and toyota is…
ODI 10328722
Frame And Members
Power doors on 2004 toyota sienna snapped. One door will not open even manually. The dealer tells me the hinge is broken. The van is only 7 years old and never in an accident, also garage kept. Toyota will fix the doors for 2,000 a door. If there was an accident it would be impossible to remove the passengers in the back of the van. *tr
ODI 10314465
Frame And Members
Power sliding door cable snapped, rear panel window shattered, hinge failed - my son went to open door from outside and it seemed to fall off track - back was lower and in trying to shut door, when pressed power button again the rear panel window shattered; dealership said hinge needs to be replaced, and that the cable had snapped but they had never seen anything like this before. Had shown the car to dealership…
ODI 10274632
Frame And Members
The automatic sliding door on my 2004 toyota sienna stopped working. The door now only opens about 12 to 18 inches. *tr
ODI 10269316
Frame And Members
Passenger side sliding door cable shredded and no longer operates door. *tr
ODI 10261644
Frame And Members · Latches/Locks/Linkages
Driver side passenger door on the toyota sienna 2004 vehicle with less than 51,000 miles must now be replaced at a cost of $1,800. This is certainly not normal for a car this new with only normal daily use in a non-weathered environment. *tr
ODI 10259814
Frame And Members
I have 2004 sienna and sliding doors have been freezing during winter. I called toyota and they said there will not cover because its out of warranty. The put the tsb 0028-08 on april 3, 2008 way after 36 mons/36,000 mile warranty my van was put in service. If i would have taken on the same day when this bulletin was released, my van would have been out of warranty. Either they should have put this bulletin earlier…
ODI 10251819
Frame And Members
2004 toyota sienna - manual sliding door latch has bolts that have ripped through the sheet metal of the door causing the door to not close properly. Toyota states this is beyond warranty but i argue that it's a safety issue and a defect which should not be limited to the warranty. They disagree. *tr
ODI 10247829
Frame And Members
Tl*the contact owns a 2004 toyota sienna. The contact stated that the cable that runs through the door was rusted. After use, the cable snapped in half and was hanging outside the vehicle. The contact cut the cable because she did not want the vehicle to be scratched. The dealer stated that the entire door needed to be repaired at the contact's expense. The failure and current mileages were 67,000.
ODI 10244207
Frame And Members
My 2004 toyota sienna xle has the driver's side automatic sliding door (for passengers in the back) that occasionally will not open, other times will not close, and sometimes after opening it will close uncommanded. In my opinion this is definitely a safety issue that toyota is unwilling to recognize. This problem is widely reported by several toyota sienna owners. Also, should a rapid escape from the car be…
ODI 10254864
Frame And Members · Latches/Locks/Linkages
Rear sliding door cable broke. Very expensive to repair ($1600) no help from dealership. Told me to call manufacturer. Car had 50,000 miles. Seems like this should not fail at all. *tr
ODI 10249726
Frame And Members
On 2/13/2008, i tried to open my passenger slider door with the auto button. The door opened approximately a foot then closed itself. I tried this a second time and again it happened. My husband then tried to open the door manually and the door would not open further than about a foot again. My husband checked the door and upon inspection noticed that the cable was broken. We called toyota and found that at the time…
ODI 10237514
Frame And Members
When the temperature drops below freezing both sliding doors on my sienna 2004 freeze shut. *tr
ODI 10254658
Body · Frame And Members · Fuel System, Gasoline
The fuel pipe from the tank to the engine on my 2004 toyota sienna le disconnected. I was driving with my kids and stopped at the light, our car being the first in the rightmost lane at a busy intersection. When the light turned green i pressed the accelerator but the car didn't move. I made several more attempts but it was in vain. The message on the screen panel appeared as a discharged battery, which at that…
ODI 10235316